Product ID:520 ADHESIVE
MSDS Date:03/19/1993
FSC:8040
NIIN:00-826-2936
Status Code:A
MSDS Number: CJVJQ

ARMSTRONG WORLD INDUSTRIES INC

313 W LIBERTY ST
LANCASTER, PA 17604
US

Emergency Phone: 800-255-3924

Info Phone: 717-396-2328; 717-396-2935

Cage: 03938

BARTELLS E J CO THE

RENTON, WA 98055-2911 US

Telephone: 425-228-4111

Cage: 4E767

ACETONE

CAS: 67-64-1

RTECS: AL3150000

OSHA PEL 2400 MG/M3;1000 PPM

ACGIH TLV: 1780 MG/M3;750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 100 PPM

ACGIH TLV: 188 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

HEXANE

CAS: 110-54-3

RTECS: MN9275000

OSHA PEL 1800 MG/M3;500 PPM

ACGIH TLV: 50 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

SYNTHETIC RUBBER

CAS: 9010-98-4

RTECS: EI9640000

PHENOLIC RESIN

RUBBER CURING INGREDIENTS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN AND EYES: EXCESSIVE SKIN CONTACT
MAY CAUSE DRYING AND CRACKING OF SKIN, AND RESULT IN DERMATITIS.
CONTACT WITH EYES WILL CAUSE IRRITATION. INHALATION: IRRITATION OF
RESPIRATORY TRACT, COUGHING, H EADACHE, DIZZINESS, DROWSINESS,
NAUSEA,UNCOORDINATED MOVEMENTS. TARGET ORGANS: SKIN, LUNGS. NOTE:
TOLUENE APPEARS ON THE NAVY LIST OF OCCUPATIONAL CHEMICAL
REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM APPROPRIATE HEALTH
PROFESSIONALS CONCERNING THE LATEST HAZARD LIST INFORMATION AND
SAFE HANDLING AND EXPOSURE INFORMATION .
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ANY CONDITION GENERALLY AGGRAVATED
BY SOLVENTS; PREEXISTING UPPER RESPIRATORY AND LUNG DISEASE SUCH
AS, BUT NOT LIMITED TO BRONCHITIS, EMPHYSEMA, AND ASTHMA.

First Aid:SKIN: FLUSH ANY SKIN CONTACT WITH PLENTY OF WATER.
ADDITIONALLY, WITH SKIN CONTACT, WASH WITH SOAP AND WATER. REFER TO
MD IF IRRITATION OR SYMPTOMS PERSIST. EYES: FLUSH ANY EYE CONTACT
WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REFER TOMD IF
IRRITATION OR SYMPTOMS PERSIST. INHALATION: REMOVE TO FRESH AIR IF
EXPOSED TO EXCESS CONCENTRATIONS OF VAPOR. SEEK MEDICAL ATTENTION
IF SYMPTOMS PERSIST. I NGESTION: CALL MD IMMEDIATELY .

Flash Point Method:PMCC
Flash Point:<-6.5C, 20.F
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, HALON.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS IN A FIRE MAY RUPTURE
DUE TO PRESSURE BUILD-UP; USE WATER TO COOL CONTAINERS TO PREVENT
THIS. NFPA 704: HEALTH - 2; FIRE - 3; REACTIVITY - 0.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION VENTILATE AREA
OF SPILL OR LEAK; IF USING MECHANICAL VENTILATION, MAKE SURE THAT
IT IS EXPLOSION-PROOF OF DOES NOT PRESENT AN IGNITION SOURCE. FOR
EXPOSURE ABOVE TLV, WE AR NIOSH APPROVED RESPIRATORY
EQUIPMENT.CONTAIN SPILL, PREVENTING IT FROM ENTERING SEWER LINES OR
WATERWAYS. USE ABSORBENT TO ASSIST WITH PICK-UP OF MATERIAL. SCRAPE
UP ADHESIVE & PLACE IN CONTAINER.

Handling and Storage Precautions:STORE IN AREAS SUITABLE FOR FLAMMABLE
MIXTURES. RECOMMENDED STORAGE TEMPERATURE IS BELOW 90F.
Other Precautions:VAPORS ARE FLAMMABLE AND ARE HEAVIER-THAN-AIR.
PROHIBIT SMOKING AND ELIMINATE ALL OTHER SOURCES OF IGNITION, SUCH
AS REGULAR ELECTRICAL TOOLS AND APPLIANCES, MAKING SURE THAT PILOTS
ON GAS-FIRED WATER HEATERS ARE EXTINGUISHED.

Respiratory Protection:WITH ADEQUATE VENTILATION, RESPIRATORY EQUIPMENT
SHOULD NOT BE NEEDED. IF ADEQUATE VENTILATION IS NOT AFFORDED, WEAR
NIOSH APPROVED RESPIRATORY EQUIPMENT FOR ORGANIC VAPORS.
Ventilation:USE NTRL CROSS-VENT, LOC (MECH) PICK-UP, &/OR GEN AREA
(MECH) VENT TO PVNT ACCUM OF SOLV VAPS, KEEPING IN MIND THAT VENT
PATTERN MUST REMOVE HVR/AIR (SUPP DATA)
Protective Gloves:DURING MFR & PACKAGING OF PROD, IMPERVIOUS GLOVES MAY
BE APPROP. DURING(SUPDAT)
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Supplemental Safety and Health
PHYSICAL DATA: % VOLAT (BY WT):75 (30 MIN @ 275F). -- VENT:SOLV VAPS
FROM LOWER LEVELS OF WORK SPACES. VENT SHOULD BE SUFFICIENT TO KEEP
SOLV VAP CONC BELOW TLV. -- PROT GLOVES:NORMAL END-PROD USE, CO
TTON OR LOOP-PILE GLOVES ARE RECOMMENDEDTO PREVENT CONTACT WITH
THIS MASTIC PRODUCT.

Boiling Pt:>66.7C, 152.F
Vapor Pres:N/K (MM HG @ 20C)
Vapor Density:N/K(AIR=1)
Spec Gravity:0.83 (H*2O=1)
Evaporation Rate & Reference:N/K (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:STRAW COLORED LIQUID WITH CHARATERIZED SOLVENT
ODOR.
Percent Volatiles by Volume:SUPP DATA

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER TOXIC VAPORS AND GASES THAT ARE COMMON TO THERMAL DEGRADATION
OF ORGANIC COMPOUNDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:INCINERATION OR OTHER METHOD APPROVED FOR
IGNITABLE WASTES I/A/W FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DEPARTMENT OF TRANSPORTATION INFORMATION:
SHIPPING NAME: ADHESIVE (HEXANE & ACETONE). HAZARD CLASS: FLAMMABLE
LIQUID. ID #: UN 1133. REPORTABLE QUANTITY (RQ): 6667 LBS.

SARA Title III Information:THIS PRODUCT CONTAINS CHEMICALS SUBJECT TO
THE REPORTING REQUIREMENTS OF 313 OF TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372.
State Regulatory Information:WARNING: THIS PRODUCT CONTAINS TOLUENE, A
CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR
OTHER REPRODUCTIVE HARM.